close
close

Harley Primary Cover Torque Specs

You should be using your service manual for. #2 · jan 30, 2007.


Primary And Inspection Covers Torque Specs Harley Davidson Forums

I just ordered chrome covers for my 07 dyna superglide.

Harley primary cover torque specs. The next service manual picture is of the final torque for the compensating sprocket bolt on a 2015 street glide special with a 103: A 2006 harley davidson street bob changing primary cover.torque specs i have a 2006 harley davidson street bob changing primary cover to crome cover. The primary oil can be changed with the bike on the kickstand or in a upright position.

There are 5 long and 5 short screws, so be sure to make note of where each type goes. Shovelhead, torque, torque specs, mechanic. I drained the oil and took of my primary and derby cover put the new gasket on.

Installation requires separate purchase of narrow derby cover, derby cover gasket and primary gasket. Then, with a pencil, make a witness mark on both the cylinder head and head bolt. Primary oil drain bolt torque:

If the inner primary cover does not step down right in the front but remains full size all the way to the outer primary, the rotor and stator will come out without having to pull the inner. Fastener torque values fastener torque values in this chapter the table below lists torque values for all fasteners presented notes 5.6 clutch, clutch pack only 5.4 drive components, installation 5.4 drive components, installation 5.4 drive components, installation/loosen then final tighten 5.5 primary chaincase housing,. The opening in the inner primary is large enough for the rotor to come out without having to pull the inner primary.

For what part?if you mean heads,65 lbs ft ,in a skip star pattern just like lug nuts.if not,be a bit more specific. None are critical, close is good, even is better. The screws are tightened in bottom to top sequence.

Park on a level surface where the service will be performed. Instant repair help over the phone. Torque specs primary cover 2005 electraglide.

Yep, called the service manual not sure if anyone has posted the specs on the forum. I just ordered chrome covers for my 07 dyna superglide. If you are unsure of the proper torque value to use, here is a general chart of fastener torque values.

Till they bottom and about 1/4 turn with your wrist.they dont come loose. This is a perfect example on a critical drive component as to why you should not be asking about torque specifications. Minton explains that the procedure requires the use of a torque wrench but not for final tightening.

Torque specs i use for my ultra: Shaped to slim the bike's profile on the left side, this narrow profile outer primary cover clears the way for an easier reach to the ground. An expert that has 1 follower.

Refer to your service manual for locations of serial stamp locations and for complete specifications of your year and model motorcycle. Starting with the bottom screw to the left of the drain plug, then the one directly above it, then one to left of the first screw.


25701020 Harley-davidson Motor Co Black Derby Cover Motorcycle Accessories Motors Suneducationgroupcom


Harley Outer Primary Cover Bolts Promotions


Torque Specs – Harley Davidson Forums


Torque Specifications For Clutch Mainshaft Nut – Harley Davidson Forums


Primary Noise – Harley Davidson Forums


2002 Compensating Sprocket Torque Procedure Harley Davidson Forums


Little Help Needed After Taking Off Derby And Primary Covers – Page 2 – Harley Davidson Forums


Torque Specs – Harley Davidson Forums


Torque Spec Harley – Fasrfocus


How To Change Primary Cover Gasket On Harley Davidson – Youtube


Harley Inner Outer Primary Housing Clutch Compensator Sprocket Chain Removal-diy – Youtube


Torque Specs Seem Off Repair Manual Verses What Everyone Says – The Herd


Looking For Torque Specs Help Needed V-twin Forum


Torque Specs – Harley Davidson Forums


How To Remove The Primary Cover Off Your Sportster Harley Davidson Forums


Derby Cover – Harley Davidson Forums


Flh 4 Speed Transmission Mounting To Plate Torque Specs Needed V-twin Forum


Solved Whats Outer Primary Cover Torque Speks – Fixya


2002 Compensating Sprocket Torque Procedure Harley Davidson Forums

Add a Comment

Your email address will not be published.